This manual is divided into different areas to assist you with your installation and operation of your steering box support system. This product is not a replacement for a new steering box and/or ball joints, but it will aid in reducing the stress placed on the steering box and associated wear. All steering components should be checked and replaced if necessary prior to addition of the steering box support. Installation should occur on a vehicle properly secured to prevent rolling. Application of lubrication at regular chassis lube intervals will promote bearing life.
Read the rest of this entry »

• 0 Comments

The engine can be turned off without locking the steering wheel ACC Accessories 2 This position activates electrical accessories such as the radio when the engine is not running ON Normal operating position 3 This position turns on the ignition system and the electrical accessories Starting and driving.
Read the rest of this entry »

• 0 Comments

utomatic transmission fluid 8 14 Temperature conditions for checking 8 15 Power steering fluid 8 17 Brake and clutch fluid 8 17 Brake fluid 8 17 Clutch fluid 8 18 Window washer fluid 8 18 Window washer fluid reservoir 8 18 Battery 8 19 Jump starting 8 20 Drive belts 8 21 Spark plugs 8 22 Replacing spark plugs 8 22 Air cleaner 8 23 In cabin Microfilter if so equipped 8 23 Windshield wiper blades 8 26 Cleaning 8 26 Replacing 8 26 Parking brake and brake pedal 8 27 Checking parking brake 8 27 Checking brake pedal 8 27 Brake booster 8 28 Fuses 8 29 Engine compartment 8 29 Passenger compartment 8 30 Battery replacement 8 31 Lights 8 33 Headlights 8 33 Fog lights if so equipped 8 34 Exterior and interior lights 8 35
Read the rest of this entry »

• 0 Comments

Press the CLOCk button to set hours then use the buttons to adjust 02 01 or Press the CLOCk button again to set minutes then use the or buttons to adjust Press the CLOCk button again to exit clock set mode INTERIOR TRUNk LID RELEASE REMOTE kEyLESS ENTRy SySTEM if so equipped LOCk DOORS Press the LOCk button to lock all doors UNLOCk DOORS Press the UNLOCk button once to unlock the driver s door only Press the button again within 5 seconds to unlock all doors RELEASING TRUNk LID This easy to use Quick Reference Guide is intended to help you more fully appreciate some of the unique features and functions of your new vehicle However it is not intended to replace your Owner s Manual
Read the rest of this entry »

• 0 Comments

Disassembly
1. WARNING: To reduce the risk of serious personal injury, read and follow all warnings, notes and instructions in the steering column removal and installation procedure.
Remove the steering column. For additional information, refer to Steering Column in this section.
2. Remove the clockspring. For additional information, refer to Section 501-20B.
3. Remove the multifunction switch.
4. Unclip the steering column opening gearshift lever seal from the steering column.
Read the rest of this entry »

• 0 Comments

Transmission selector lever lock release 5 10 B Battery 8 17 Battery Charge warning light 2 8 Battery replacement See multi remote control system 3 8 Before starting the engine 5 6 Belts See drive belts 8 19 Brake Anti lock brake system ABS 5 19 Brake booster 8 24 Brake fluid 8 15 Brake light See stop light.
Read the rest of this entry »

• 0 Comments

The information contained in this TSB supersedes TSB No. ST001-06. • Applicability has been updated to include 2005 – 2006 model year Avalon and 2006 model year Highlander HV. • Production Change information has been removed. • The Introduction, Warranty Information, Parts Information, and Repair Procedure sections have been updated to reflect removal, lubrication, and reinstallation of the steering intermediate shaft instead of replacement. TSB No. ST001-06 is Obsolete and any printed versions should be discarded. Be sure to review the entire content of this service bulletin before proceeding.
Read the rest of this entry »

• 0 Comments

The steering system consists of solid steering shaft with a lower joint assembly. Stealth and 3000GT models are equipped with a Supplemental Restraint System (SRS) that includes an air bag and clockspring located in the steering column. WARNING: On Stealth and 3000GT, before doing any repairs, disconnect and shield battery ground. Disconnect SRS connector at control unit. Use caution when working around steering column (air bag could deploy).
Read the rest of this entry »

• 0 Comments

Parrot MULTICOMM is a unit able to control Parrot H/F kits with the car’s steering wheel commands working with ANALOG STEERING WHEEL COMMANDS with OEM headunit installed.
This unit is available in two versions, one working with the CK3000 Evolution, another for the CK3100.
Read the rest of this entry »

• 0 Comments

Before performing the following procedures, disconnect the ABS wheel-speed sensor connector (axle side) and fix the wiring harness to an appropriate place where it will not be pulled by mistake while servicing the vehicle.
1. Remove in the order indicated in the table.
Read the rest of this entry »

• 0 Comments