Ford Motor Company and your selling dealer thank you for selecting one of our quality products. Our commitment to you and your vehicle begins with quality protection and service. When you need warranty repairs, your selling dealer would like you to return to it for that service, but you may also take your vehicle to another Ford Motor Company dealership authorized for warranty repairs.
Read the rest of this entry »

• 0 Comments

P1711 Engine Torque Control Signal 1 Circuit Malfunction – With Automatic Transmission
Possible Causes
Communication circuit between to the TCM is open or shorted to ground PCM connector is damaged (check pins for damage, and for moisture) TCM connector is damaged (check pins for damage, and for moisture)
Setting Conditions
Engine speed more than 500 rpm; system voltage over 8.0v, and the PCM detected an unexpected high voltage condition on the Engine Torque Control Signal 1 circuit. This code sets in 2 Trip(s). This code will turn on the MIL (Malfunction Indicator Lamp)
Read the rest of this entry »

• 0 Comments

Remove the turbocharger system from its carton and inspect for any obvious physical damage. All kit components are thoroughly inspected and carefully packaged prior to shipment from the factory. If any shipping damage is evident, contact your supplier and request that they process a claim with the shipper involved. Be sure to review the parts list on page 3 & 4 to verify that you have all necessary system components to proceed. If any components in the parts list are missing, contact Turbonetics’ customer service staff.
Read the rest of this entry »

• 0 Comments

ENGINE CRANKSHAFT CYLINDER BLOCK – 2.0 LITER ENGINE CODE ABA Model(s): 1996-on Volkswagen Golf III, Jetta III, Cabrio Group: 13 – Engine – Crankshaft/Crankcase Bulletin No.: 95-01 Date: October 16, 1995 File this Technical Bulletin in Repair Manual No.: W42 011 294 105. This information describes changes in engine components and specifications for the 2.0 liter engine starting with August, 1995 production (OBD II). The following information will be integrated into the Repair Manual during the next update. PISTON AND CONNECTING ROD Read the rest of this entry »

• 0 Comments

Some 1999-2004 Navigator, 2002-2003 Blackwood, 2003-2005 Aviator, 2003-2004 Marauder and 2003-2004 Mustang vehicles built before 12/19/2004 equipped with 4.6L 4V/5.4 4V engine may exhibit a runs rough, lacks power, and engine misfire, prompted by a MIL light and DTC codes P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308, and P0316.
Read the rest of this entry »

• 0 Comments

Installation Procedure:
1. On left wall of trunk, remove the three fasteners that secure the trunk liner.
2. Remove Velcro attached net storage if equipped.
3. Open left rear passenger door fold down seat and remove two remaining fasteners that secure trunk liner.
4. Remove trunk liner.
5. Using Router Docking Station as a template, drill or punch four 1/8” diameter holes in level area near rear of trunk liner. Use caution-insulation located behind this area can bind in drill bit.
6. Attach docking station using four supplied nylon Key Hole clips.
Read the rest of this entry »

• 0 Comments

Terrain management adapts the responses of the vehicle’s engine, transmission, 4WD system, and stability control system to match the demands of the terrain. It optimizes driveability and comfort as well as maximizing traction. The terrain management knob located on the center console can be shifted on the fly, enabling the following settings:
Snow
this program should be used where a firm surface is covered with loose or slippery material. Surfaces covered in packed snow, ice, water, grass, gravel or a thin coating of sand, for example.
Read the rest of this entry »

• 0 Comments

Engine, removing and installing Note: All cable ties opened or cut during engine removal must be reinstalled at the same locations. Remove engine without transmission toward the front. Drained coolant must be stored in a clean container for disposal or reuse. Always replace seals and gaskets. Do not open coolant circulation system.
Read the rest of this entry »

• 0 Comments

Entertainment Systems – FLO TV
FLO TV`99 service provides a superior mobile TV experience that is available to over 200 million people in 105 major U.S. markets. Many key transportation corridors will be covered by the FLO TV network and coverage will extend to 95 percent of where these Americans live, work, drive. That means that you can receive 24/7 programming to keep your entire crew entertained, regardless of the trip duration. Even if you`ve got to keep your eyes on the road, you can enjoy listening to 60 Minutes from CBS Mobile or the
Read the rest of this entry »

• 0 Comments

INSPECTION SERVICE POINTS FOR A BLOWN FUSE Remove the fuse and measure the resistance between the load side of the fuse and ground. Set the switches of all circuits which are connected to this fuse to a condition of continuity. If the resistance is almost 0 Ω at this time, there is a short somewhere between these switches and the load. If the resistance is not 0 Ω, there is no short at the present time, but a momentary short has probably caused the fuse to blow.
Read the rest of this entry »

• 0 Comments