The following procedures for removing the fan clutch gives the factory recommended loosening and tightening directions for the fan hub nut. However, it has been our experience that certain aftermarket parts manufacturers have changed this to enable use of universal fit parts. We recommend trying the factory direction first, then, if the nut doesn’t seem to be moving, reverse the direction. Placing too much load on the water pump snout will break it.
Read the rest of this entry »

• 0 Comments

The Ford Explorer’s brake system is a relatively robust and trouble-free system. But, that doesn’t mean something can’t go wrong. The Ford Explorer is one of the most common vehicles on our roads. The system is a product of what Ford learned in the late 1990s about brake systems and what it means to customer satisfaction. It is a relatively robust and trouble-free system. But, it does not mean something cannot go wrong. The Explorer’s brake system has large enough rotors and pad surface to safely bring the vehicle to a stop and the rotors can last at least the first two brake jobs depending on the driver. The calipers can last more than 100,000 miles before they might require replacement.
Read the rest of this entry »

• 0 Comments

Part Contents: Hi! I’m Zach Telford, and you’ve downloaded my subwoofer box plans for 1 and 2nd Gen. Ford Explorers and Mercury Mountaineers. As a forewarning, this design has only been tested on a 2nd Gen. Ford Explorer XLT. Ok, now a little bit of background. I’m a 20-yr-old Russian translator for the military. My dad is a contractor, but I grew up with my mom. I spent my summers with dad and learned a little bit about woodworking, but it was mainly framing. I’m really good with math, but this box really only required some basic geometry (Pythagorean and SOHCAHTOA).
Read the rest of this entry »

• 0 Comments

You AC should be cooling more effectively than that on MaxAC − I’d take it back and get the pressure checked to ensure you don’t have a leak. Something is funny about your problem though as MaxAC should work even with a bad blend door. MaxAC opens the recirculating air damper, shuts off the flow to the heater core and cranks the AC so you should get full cooling. If you look on this picture below you will see how it all is setup − the blend door is in the middle and controls air flow around the heater core after the AC evaporator. If the heater core is off then you should still get full cooling even if the blend door is wonky.
Read the rest of this entry »

• 0 Comments

Explorer delivers versatility and rugged capabilities with the guts to meet the hectic demands of your lifestyle. With towing of up to 7,115 pounds, the choice of a spirited 292 hp 4.6L V8 engine and seating for up to seven passengers, Explorer is designed to deliver.
KEY FEATURES
• Standard 210 hp 4.0L SOHC V6 engine with 5-speed automatic transmission
• Optional 292 hp 4.6L 3-valve V8 engine with 6-speed automatic transmission
• Tows trailers up to 7,115 lbs. when properly equipped (4.6L V8/4×4)
• Independent rear suspension tackles rough terrain and uneven road surfaces with ease
Read the rest of this entry »

• 0 Comments

Some vehicles may exhibit clutch chatter or judder when releasing the clutch during cold conditions. This concern may be caused by the clutch surface materials creating a chatter or judder during clutch engagement. Customers experiencing this concern should have their vehicle repaired using this repair procedure.
Read the rest of this entry »

• 0 Comments

The Boxster is now in its sixth model year and proving to be one of the most popular models Porsche has ever built. The used market is proving to be good and many fine early examples can be found reasonably priced in comparison to other marques. I am of the mind that a used Porsche is still a much better buy than something new and cheaper for other Read the rest of this entry »

• 0 Comments

In the late 1990’s and early 2000’s several accidents were reported of Ford Explorers equipped with Firestone tires rolling over as a consequence of tires’ failures. By the end of 2000 the death toll was estimated at more than 250, and some 3,000 incidents had been associated with ‘defective’ Firestone tires mounted on Ford Explorers. These problems were frequently encountered in Saudi Arabia and Venezuela but also occurred in mid-western US. The US reports triggered a crisis for the two companies.
Read the rest of this entry »

• 0 Comments

To increase the durability of the clutch in 2.4L manual transaxle Santa Fe vehicles, the Dual Mass Flywheel and its components may be replaced with the Single Mass Flywheel (SMF) system in accordance with the applicable Shop Manuals’ replacement procedures.
AFFECTED VEHICLES: All Santa FE (SM) 2.4L vehicles with manual transaxles produced through July 16, 2003.
Read the rest of this entry »

• 0 Comments

Volkswagen > A3 Platform > 1993 – 2002 5 Spd. Manual Transmission 020 34 – Manual Transmission – Controls, Housing Clutch housing, servicing 1 – Oil drain plug Without magnet 25 Nm (18 ft lb) 2 – Dowel sleeve Qty: 2 Shim S2 Always 1 mm thick (0.04 in.) 4 – Outer race of tapered roller bearing for differential Removing and installing => page 39-5 When replacing: adjust differential => page 39-17 5 – Magnet Retained in housing joint surface Install with AMV 188 200 03 sealant 6 – Shim S3 Adjustment summary => page 39-16 7 – Outer race for output shaft tapered roller bearing Removing and installing => page 35-14 When replacing: adjust output shaft => page 35-27 8 – Needle bearing for input shaft Removing => Fig. 1 Installing => Fig. 2 9 – Bolt With locking teeth 25 Nm (18 ft lb) 10 – Relay lever 11 – Spring 12 – Read the rest of this entry »

• 1 Comment